MODEL 463360408 • PRODUCT GUIDE
THIS GRILL IS FOR OUTDOOR USE ONLY.
CAUTION:
WARNING:
Read and follow all safety statements, assembly
instructions, and use and care directions before
attempting to assemble and cook.
Failure to follow all manufacturer’s instructions could
result in serious personal injury and/or property
damage.
INSTALLER/ASSEMBLER:
CAUTION:
Leave this manual with consumer.
Some parts may contain sharp edges – especially as
noted in the manual! Wear protective gloves if
necessary.
CONSUMER:
Keep this manual for future reference.
If you have questions or need assistance during assembly, please call 1-800-241-7548.
To insure your satisfaction and for follow-up service, register your grill online at www.grillregistration.com
463360408 • 80015625 • 10-23-07
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
TABLE OF CONTENTS
For Your Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Grill Service Center. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Safety Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Use and Care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Parts List. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Parts Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-22
Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-25
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
To insure your satisfaction
and for follow-up service,
register your grill
online at:
463360408 • 3
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
LP Cylinder
USE AND CARE
• The LP cylinder used with your grill must meet the
following requirements:
• Use LP cylinders only with these required measurements: 12"
(30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.)
capacity maximum.
• LP cylinders must be constructed and marked in accordance
with specifications for LP cylinders of the U.S. Department of
Transportation (DOT) or for Canada, CAN/CSA-B339,
cylinders, spheres and tubes for transportation of dangerous
goods. Transport Canada (TC). See LP cylinder collar for
marking.
DANGER
• NEVER store a spare LP cylinder under or near
the appliance or in an enclosed area.
• LP cylinder valve must have:
• Type 1 outlet compatible with
regulator or grill.
• Safety relief valve.
• UL listed Overfill Protection
Device (OPD). This OPD safety
OPD Hand Wheel
feature is identified by a unique triangular hand wheel. Use
only LP cylinders equipped with this type of valve.
• LP cylinder must be arranged for vapor withdrawal and include
collar to protect LP cylinder valve. Always keep LP cylinders in
upright position during use, transit or storage.
• Never fill a cylinder beyond 80% full.
• An over filled or improperly stored cylinder is a
hazard due to possible gas release from the
safety relief valve.
• If you see, smell or hear gas escaping,
immediately get away from the LP
cylinder/appliance and call your fire department.
LP cylinder in upright position for vapor withdrawal
• This could cause an intense fire with risk of
LP (Liquefied Petroleum Gas)
• LP gas is nontoxic, odorless and colorless when produced. For
Your Safety, LP gas has been given an odor (similar to rotten
cabbage) so that it can be smelled.
property damage, serious injury or death.
LP Cylinder Removal, Transport and Storage
• Turn OFF all control knobs and LP cylinder valve. Turn coupling
nut counterclockwise by hand only - do not use tools to
disconnect. Loosen cylinder screw beneath bottom shelf, then
lift LP cylinder up and out of cart. Install safety cap onto LP
cylinder valve. Always use cap and strap supplied with valve.
Failure to use safety cap as directed may result in serious
personal injury and/or property damage.
• LP gas is highly flammable and may ignite unexpectedly when
mixed with air.
LP Cylinder Filling
• Use only licensed and experienced dealers.
• LP dealer must purge new cylinder before filling.
• Dealer should NEVER fill LP cylinder more than 80% of LP
cylinder volume. Volume of propane in cylinder will vary by
temperature.
LP Cylinder Valve
• A disconnected LP cylinder in
storage or being transported
• A frosty regulator indicates gas overfill. Immediately close LP
must have a safety cap installed (as shown).
Do not store an LP cylinder in enclosed spaces
such as a carport, garage, porch, covered
cylinder valve and call local LP gas dealer for assistance.
• Do not release liquid propane (LP) gas into the atmosphere.
This is a hazardous practice.
Safety
patio or other building. Never leave an LP cylinder
• To remove gas from LP cylinder, contact an LP dealer or call a
local fire department for assistance. Check the telephone
directory under “Gas Companies” for nearest certified LP
dealers.
Cap
inside a vehicle which may become overheated
Retainer Strap
by the sun.
• Do not store an LP cylinder in an area where children play.
4 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
LP Cylinder Exchange
Connecting Regulator to the LP Cylinder
• Many retailers that sell grills offer you the option of replacing
your empty LP cylinder through an exchange service. Use only
those reputable exchange companies that inspect, precision fill,
test and certify their cylinders. Exchange your cylinder only
for an OPD safety feature-equipped cylinder as described
in the "LP Cylinder" section of this manual.
1. LP cylinder must be properly secured onto grill. (Refer to
assembly section.)
2. Turn all control knobs to the OFF position.
3. Turn LP cylinder OFF by turning hand-wheel clockwise to a
full stop.
• Always keep new and exchanged LP cylinders in upright
4. Remove the protective cap from LP cylinder valve. Always use
position during use, transit or storage.
cap and strap supplied with valve.
• Leak test new and exchanged LP cylinders BEFORE
connecting to grill.
LP Cylinder Leak Test
For your safety
OPD Hand Wheel
• Leak test must be repeated each time LP cylinder is exchanged
Type 1 outlet with
thread on outside
or refilled.
• Do not smoke during leak test.
Safety Relief Valve
• Do not use an open flame to check for gas leaks.
• Grill must be leak tested outdoors in a well-ventilated area,
away from ignition sources such as gas fired or electrical
appliances. During leak test, keep grill away from open flames
or sparks.
Strap and Cap
• Use a clean paintbrush and a 50/50 mild soap and water
solution. Brush soapy solution onto areas indicated by arrows
in figure below.
Do not use a POL transport plug
(plastic part with external threads)!
It will defeat the safety feature of
the valve.
s
Do not use household cleaning agents. Damage to gas
train components can result.
5. Hold regulator and insert nipple into LP
cylinder valve. Hand-tighten the
coupling nut, holding regulator in a
straight line with LP cylinder valve so
as not to cross-thread the connection.
Nipple has to be centered
into the LP cylinder valve.
WARNING
If “growing” bubbles appear do not use or move the LP
cylinder. Contact an LP gas supplier or your fire
department!
463360408 • 5
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
Leak Testing Valves, Hose and Regulator
1. Turn all grill control knobs to OFF.
2. Be sure regulator is tightly connected to LP cylinder.
3. Completely open LP cylinder valve by turning hand wheel
counterclockwise. If you hear a rushing sound, turn gas off
immediately. There is a major leak at the connection. Correct
before proceeding.
4. Brush soapy solution onto areas where bubbles are shown in
Hold coupling nut and regulator
as shown for proper connection
to LP cylinder valve.
picture below:
s
Never remove threaded
orifice at end of valve.
6. Turn the coupling nut clockwise and tighten to a full stop. The
regulator will seal on the back-check feature in the LP cylinder
valve, resulting in some resistance. An additional one-half to
three-quarters turn is required to complete the
connection. Tighten by hand only – do not use tools.
NOTE:
If you cannot complete the connection, disconnect regulator and
repeat steps 5 and 6. If you are still unable to complete the
connection, do not use this regulator!
DANGER
• Do not insert any tool or foreign object into the valve
outlet or safety relief valve. You may damage the valve
and cause a leak. Leaking propane may result in
explosion, fire, severe personal injury, or death.
5. If “growing” bubbles appear, there is a leak. Close LP
cylinder valve immediately and retighten connections. If leaks
cannot be stopped do not try to repair. Call for replacement
parts. Order new parts by giving the serial, model number and
name and part number of items needed (see parts list) to the
Grill Service Center at 1-800-241-7548.
WARNING
• Outdoor gas appliance is not intended to be installed
6. Always close LP cylinder valve after performing leak test by
in or on a boat.
• Outdoor gas appliance is not intended to be installed
in or on an RV.
turning hand wheel clockwise.
• Never attempt to attach this grill to the self-contained
LP gas system of a camper trailer or motor home.
• Do not use grill until leak-tested.
• If a leak is detected at any time, STOP and call the fire
department.
• If you cannot stop a gas leak, immediately close
LPcylinder valve and call LP gas supplier or your fire
department!
6 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
Safety Tips
sBefore opening LP cylinder valve, check the coupling nut for
WARNING
tightness.
s
When grill is not in use, turn off all control knobs and LP
For Safe Use of Your Grill and to Avoid Serious
cylinder valve.
Never move grill while in operation or still hot.
Use long-handled barbecue utensils and oven mitts to avoid
burns and splatters.
Maximum load for sideburner and side shelf is 10 lbs.
s
Injury:
s
• Do not let children operate or play near grill.
• Keep grill area clear and free from materials that burn.
• Do not block holes in sides or back of grill.
• Check burner flames regularly.
• Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch,
covered patio, or under an overhead structure of any
kind.
s
s
The grease tray must be inserted into grill and emptied after
each use. Do not remove grease tray until grill has
completely cooled.
s
Clean grill often, preferably after each cookout. If a bristle
brush is used to clean any of the grill cooking surfaces,
ensure no loose bristles remain on cooking surfaces prior to
grilling. It is not recommended to clean cooking surfaces
while grill is hot.
s
If you notice grease or other hot material dripping from grill
• Do not use charcoal or ceramic briquets in a gas grill.
onto valve, hose or regulator, turn off gas supply at once.
Determine the cause, correct it, then clean and inspect valve,
hose and regulator before continuing. Perform a leak test.
(Unless briquets are supplied with your grill.)
• Use grill at least 3 ft. from any wall or surface.
Maintain 10 ft. clearance to objects that can catch fire
or sources of ignition such as pilot lights on water
heaters, live electrical appliances, etc.
s
Keep ventilation openings in cylinder enclosure (grill cart) free
and clear of debris.
s
Do not store objects or materials inside the grill cart
enclosure that would block the flow of combustion air to the
underside of either the control panel or the firebox bowl.
s
The regulator may make a humming or whistling noise during
operation. This will not affect safety or use of grill.
s
If you have a grill problem see the "Troubleshooting Section".
s
If the regulator frosts, turn off grill and LP cylinder valve
immediately. This indicates a problem with the cylinder and it
should not be used on any product. Return to supplier!
CAUTION
• Putting out grease fires by closing the lid is not possible.
Grills are well ventilated for safety reasons.
• Do not use water on a grease fire. Personal injury may
result. If a grease fire develops, turn knobs and LP
cylinder off.
• Do not leave grill unattended while preheating or burning
off food residue on HI. If grill has not been regularly
cleaned, a grease fire can occur that may damage the
product.
• Apartment Dwellers:
Ignitor Lighting
Check with management to learn the requirements
and fire codes for using an LP gas grill in your
apartment complex. If allowed, use outside on the
ground floor with a three (3) foot clearance from walls
or rails. Do not use on or under balconies.
• NEVER attempt to light burner with lid closed. A
buildup of non-ignited gas inside a closed grill is
hazardous.
s
Do not lean over grill while lighting.
1. Turn OFF gas burner control valves.
2 Turn ON gas source or tank
3. Open lid during lighting..
4. To ignite, turn the IGNITION BURNER knob to
5. Push and hold ELECTRONIC IGNITOR button.
HIGH.
6. If ignition does NOT occur in 5 seconds, turn the burner
controls OFF, wait 5 minutes, and repeat lighting procedure.
• Never operate grill with LP cylinder out of correct
7. Ignite remaining burners by turning to
, starting with the
position specified in assembly instructions.
burners closest to the IGNITION BURNER first.
• Always close LP cylinder valve and remove
coupling nut before moving LP cylinder from
specified operation position.
If ignition still does not occur, follow match-lighting
instructions.
Lighting instructions continued on next page.
463360408 • 7
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
Burner Flame Check
• Remove cooking grates and flame tamers. Light burners, rotate
knobs from HIGH to LOW. You should see a smaller flame in
LOW position than seen on HIGH. Perform burner flame check
on sideburner, also. Always check flame prior to each use. If
only low flame is seen refer to "Sudden drop or low flame" in
the Troubleshooting Section.
WARNING
Turn controls and gas source or tank OFF when not
in use.
HIGH
CAUTION
LOW
If ignition does NOT occur in 5 seconds, turn the
burner controls OFF, wait 5 minutes and repeat the
lighting procedure. If the burner does not ignite with
the valve open, gas will continue to flow out of the
burner and could accidently ignite with risk of injury.
Turning Grill Off
• Turn all knobs to OFF position. Turn LP cylinder off by turning
hand-wheel clockwise to a full stop.
Match-Lighting
s
Ignitor Check
• Turn gas off at LP cylinder. Press and hold electronic ignitor
button. "Click" should be heard and spark seen each time
between collector box or burner and electrode. See
"Troubleshooting" if no click or spark.
Do not lean over grill while lighting.
1. Open lid. Turn on gas at LP cylinder.
2. Place lit match into match holder (hanging from cart side
panel), light burner on right or left side of grill.
Valve Check
• Important: Make sure gas is off at LP cylinder before
checking valves. Knobs lock in OFF position. To check
valves, first push in knobs and release, knobs should spring
back. If knobs do not spring back, replace valve assembly
before using grill. Turn knobs to LOW position then turn back to
OFF position. Valves should turn smoothly.
3. Push in and turn far right or far left burner knob to HIGH. Be
sure burner lights and stays lit.
4. Light adjacent burners in sequence by pushing knobs in and
turning to HIGH.
Hose Check
• Before each use, check to see if hoses are cut or worn.
Replace damaged hoses before using grill. Use only
valve/hose/regulator specified by manufacturer.
General Grill Cleaning
• Do not mistake brown or black accumulation of grease and
smoke for paint. Apply a strong solution of detergent and water
or use a grill cleaner with scrub brush on insides of grill lid and
bottom. Rinse and allow to completely air dry. Do not apply a
caustic grill/oven cleaner to painted surfaces.
• Plastic parts: Wash with warm soapy water and wipe dry.
s
concentrated grill cleaner on plastic parts. Damage to and
failure of parts can result.
Do not use citrisol, abrasive cleaners, degreasers or a
Sideburner Ignitor Lighting
s
Do not lean over grill while lighting.
1. Top cover must be open when burner is operational.
2. To ignite SIDEBURNER, open sideburner cover.
• Porcelain surfaces: Because of glass-like composition, most
residue can be wiped away with baking soda/water solution or
specially formulated cleaner. Use nonabrasive scouring powder
for stubborn stains.
3. Turn sideburner knob to HIGH, push and hold ELECTRONIC
IGNITOR button.
• Painted surfaces: Wash with mild detergent or nonabrasive
cleaner and warm soapy water. Wipe dry with a soft
nonabrasive cloth.
4. If sideburner does NOT light in 5 seconds, turn knob to OFF,
wait 5 minutes, then repeat lighting procedure.
• Stainless steel surfaces: To maintain your grill’s high quality
appearance, wash with mild detergent and warm soapy water
and wipe dry with a soft cloth after each use. Baked-on grease
deposits may require the use of an abrasive plastic cleaning
pad. Use only in direction of brushed finish to avoid damage.
Do not use abrasive pad on areas with graphics.
• Cooking surfaces: If a bristle brush is used to clean any of
the grill cooking surfaces, ensure no loose bristles remain on
cooking surfaces prior to grilling. It is not recommended to
clean cooking surfaces while grill is hot.
Sideburner Match Lighting
1. Open sideburner cover.
2. Place lit match near burner.
3. Turn sideburner knob to HIGH. Be sure burner lights and
stays lit.
8 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
Cleaning the Burner Assembly
CAUTION
Follow these instructions to clean and/or replace parts of burner
assembly or if you have trouble igniting grill.
1. Turn gas off at control knobs and LP cylinder.
2. Remove cooking grates and heat tents.
SPIDER ALERT!
3. Remove screws and carryover tubes from rear of burners.
4. Remove screw and washers to disengage burner from
bracket on firebox.
SPIDER AND WEBS
INSIDE BURNER TUBE
5. Remove screws to detach electrode from burner. Electrode
should remain in firebox.
6. Carefully lift each burner up and away from valve openings.
We suggest three ways to clean the burner tubes. Use the one
easiest for you.
(A) Bend a stiff wire (a light weight coat hanger works well)
into a small hook. Run the hook through each burner
tube several times.
If you notice that your grill is getting hard to light or that the
flame isn’t as strong as it should be, take the time to check and
clean the venturi’s.
(B) Use a narrow bottle brush with a flexible handle (do not
use a brass wire brush), run the brush through each
burner tube several times.
VALVE
(C) Wear eye protection: Use an air hose to force air into
the burner tube and out the burner ports. Check each
port to make sure air comes out each hole.
7. Wire brush entire outer surface of burner to remove food
residue and dirt.
SPIDER WEBS
CONTROL PANEL
INSIDE VENTURI
BURNER
8. Clean any blocked ports with a stiff wire such as an open
paper clip.
9. Check burner for damage, due to normal wear and corrosion
some holes may become enlarged. If any large cracks or
holes are found replace burner.
In some areas of the country, spiders or small insects have been
known to create “flashback” problems. The spiders spin webs, build
nests and lay eggs in the grill’s venturi tube(s) obstructing the flow of
gas to the burner. The backed-up gas can ignite in the venturi behind
the control panel. This is known as a flashback and it can damage
your grill and even cause injury.
VERY IMPORTANT: Burner tubes must re-engage valve
openings. See illustrations at right.
Correct
10. Attach electrode to burner.
burner-to-valve
11. Carefully replace burners.
12. Attach burners to brackets on firebox.
13. Reposition carryover tubes and attach
to burners. Replace heat tents and
cooking grates.
engagement
To prevent flashbacks and ensure good performance the burner and
venturi assembly should be removed from the grill and cleaned
before use whenever the grill has been idle for an extended period.
Storing Your Grill
• Clean cooking grates.
• Store in dry location.
• When LP cylinder is connected to grill, store outdoors in a well-
ventilated space and out of reach of children.
• Cover grill if stored outdoors. Choose from a variety of grill
covers offered by manufacturer.
• Store grill indoors ONLY if LP cylinder is turned off and
disconnected, removed from grill and stored outdoors.
• When removing grill from storage, follow “Cleaning the Burner
Assembly” instructions before starting grill.
Firebox
Electrode
burner
bracket
463360408 • 9
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
Indirect Cooking
Food Safety
Poultry and large cuts of meat cook slowly to perfection on
Food safety is a very important part of enjoying the outdoor
cooking experience. To keep food safe from harmful bacteria,
follow these four basic steps:
the grill by indirect heat. The heat from selected burners
circulates gently throughout the grill, cooking meat or poultry
without the touch of a direct flame. This method greatly reduces
flare-ups when cooking extra fatty cuts because there is no direct
flame to ignite the fats and juices that drip during cooking.
Clean: Wash hands, utensils, and surfaces with hot soapy water
before and after handling raw meat and poultry.
Separate: Separate raw meats and poultry from ready-to-eat
foods to avoid cross contamination. Use a clean platter and
utensils when removing cooked foods.
Indirect Cooking Instructions
• Always cook with the lid closed.
Cook: Cook meat and poultry thoroughly to kill bacteria. Use a
• Due to weather conditions, cooking times may vary. During
cold and windy conditions the temperature setting may need
to be increased to insure sufficient cooking temperatures.
thermometer to ensure proper internal food temperatures.
Chill: Refrigerate prepared foods and leftovers promptly.
For more information call: USDA Meat and Poultry Hotline at
1-800-535-4555 In Washington, DC (202) 720-3333, 10:00 am-
4:00 pm EST.
How To Tell If Meat Is Grilled Thoroughly
• Meat and poultry cooked on a grill often browns very fast on the
outside. Use a meat thermometer to be sure food has reached
a safe internal temperature, and cut into food to check for
visual signs of doneness.
1 Burner Cooking
Cook with direct or indirect heat.
Best for smaller meals or foods.
Consumes less fuel.
• Whole poultry should reach 180° F; breasts, 170° F. Juices
should run clear and flesh should not be pink.
• Hamburgers made of any ground meat or poultry should reach
160° F, and be brown in the middle with no pink juices. Beef,
veal and lamb steaks, roasts and chops can be cooked to 145°
F. All cuts of pork should reach 160° F.
• NEVER partially grill meat or poultry and finish cooking later.
Cook food completely to destroy harmful bacteria.
• When reheating takeout foods or fully cooked meats like hot
dogs, grill to 165° F, or until steaming hot.
2 Burner Cooking
Great indirect cooking on low.
Produces slow, even heating.
Ideal for slow roasting and baking.
10 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
CARE AND CLEANING OF YOUR STAINLESS STEEL GRILL
Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that
many people have is that stainless steel will not rust. That is not the case in certain conditions. Rust marks are regular steel
particles that have become attached to the surface of stainless steel. They may also occur if you are using a steel wool or
wire wool scouring pad instead of a nylon scouring pad to clean your grill. In coastal areas, small rust pits may develop on
the surface of your grill that cannot be fully removed by a cleaner. Concentrate bleaches and other solutions containing
chlorine can also cause rust pits and should not be used.
Cooking creates smoke that may eventually coat and discolor the stainless steel surface. Grease fires will darken the
stainless steel surface, but will not affect the integrity of the steel. Periodic cleaning of the cooking surface and inside of the
grill helps decrease the risk of a fire. The methods below are suggestions for cleaning stainless steel surfaces. Choose a
cleaning method appropriate for your needs. It is recommended that you use a Char-Broil® grill cover to help prolong the
life and prevent discoloration of your grill.
Routine Care
After each use, let your grill cool and then wipe the grill with a soft, damp, soapy cloth and rinse with clean water. It is
important to remove any food particles or marinade from the stainless steel surface of your grill. Most marinades are highly
acidic and damage stainless steel. DO NOT USE STEEL OR WIRE WOOL. To clean, polish and protect your stainless steel
grill on a weekly basis use Char-Broil® Stainless Steel Grill Cleaner. For quick, convenient cleaning, use Char-Broil®
Stainless Steel Grill Wipes.
Stubborn Stains and Rust
Stubborn stains, discoloration and possibly rust and rust pitting can occur from cooking, exposure to harsh outdoor
conditions, or extreme cooking temperatures. For stubborn rust stains and grease stains, you can restore your grill with the
Char-Broil Stainless Steel Restoration Kit. It is available at major retailers retailers or you can buy it online at
www.charbroil.com or www.grilllovers.com. For the latest new products and information for the care and cleaning of your
* Always rub or wipe in the direction of the grain or polish lines in the stainless steel surface, not across them.
** Do not let stainless steel cleaners come in contact with painted or plastic surfaces as damage may occur.
ROUTINE CARE
Char-Broil® Stainless Steel
Grill Cleaner
ROUTINE CARE
STUBBORN STAINS AND RUST
Char-Broil® Stainless Steel Char-Broil® Stainless Restoration Kit
Grill Wipes
463360408 • 11
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
PARTS LIST – Model No. 463360408
Key Qty Description
Part #
Key Qty Description
Part #
A
B
C
D
E
F
1
3
1
2
1
1
1
1
1
1
1
4
4
1
3
2
1
1
1
1
1
1
1
1
1
Firebox . . . . . . . . . . . . . . . . . . . . . . . . . 80012264
Z
1
2
2
1
1
1
1
1
1
1
1
1
1
Axle Rod. . . . . . . . . . . . . . . . . . . . . . . . 80009036
Wheels . . . . . . . . . . . . . . . . . . . . . . . . . 80009727
Leg Extenders . . . . . . . . . . . . . . . . . . . 80000076
Front Panel. . . . . . . . . . . . . . . . . . . . . . 80015639
Grease Cup Clip. . . . . . . . . . . . . . . . . . 80000271
Grease Cup . . . . . . . . . . . . . . . . . . . . . 80000270
Tank Exclusion Wire. . . . . . . . . . . . . . . 80008616
Sideburner Grate . . . . . . . . . . . . . . . . . 80000638
Sideburner Lid . . . . . . . . . . . . . . . . . . . 80015641
Tank Retainer Screw . . . . . . . . . . . . . . 80006484
Product Guide (FR) . . . . . . . . . . . . 80015625
Product Guide (Spanish) . . . . . . . . . . . 80015626
Hardware Pack. . . . . . . . . . . . . . . . . . . 80008565
Tube Burner . . . . . . . . . . . . . . . . . . . . . 80012205
Electrode, Main Burner. . . . . . . . . . . . . 80009029
Carryover Tubes. . . . . . . . . . . . . . . . . . 80009028
Lid Assembly . . . . . . . . . . . . . . . . . . . . 80012266
Logo Plate . . . . . . . . . . . . . . . . . . . . . . 80012204
Temperature Gauge w/Bezel . . . . . . . . 80009952
Handle . . . . . . . . . . . . . . . . . . . . . . . . . 80012203
Control Panel . . . . . . . . . . . . . . . . . . . . 80015634
Electronic Ignition Module . . . . . . . . . . 80012212
Valve/Hose/Regulator. . . . . . . . . . . . . . 80015870
Bezels. . . . . . . . . . . . . . . . . . . . . . . . . . 80009384
Control Knobs. . . . . . . . . . . . . . . . . . . . 80000035
Match Holder w/Chain . . . . . . . . . . . . . 80004320
Heat Tent . . . . . . . . . . . . . . . . . . . . . . . 80008530
Cooking Grate . . . . . . . . . . . . . . . . . . . 80000854
Swing Away . . . . . . . . . . . . . . . . . . . . . 80008532
Left Side Shelf . . . . . . . . . . . . . . . . . . . 80015637
Sideburner, W/ Electrode . . . . . . . . . . . 80015596
Left Fascia . . . . . . . . . . . . . . . . . . . . . . 80015638
Right Side Shelf . . . . . . . . . . . . . . . . . . 80015635
Right Fascia . . . . . . . . . . . . . . . . . . . . . 80015636
Right Cart Frame . . . . . . . . . . . . . . . . . 80012278
Left Cart Frame . . . . . . . . . . . . . . . . . . 80012279
Bottom Shelf. . . . . . . . . . . . . . . . . . . . . 80009035
AA
BB
CC
DD
EE
FF
GG
HH
II
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
1
2
1
Sideburner Cap Clip
Wheel Spacer
Axle Washer
12 #1/4-20x1/2" Machine Screws
4
4
4
#1/4-20x1-1/2" Machine Screws
Lock Washers, 7MM
Flat Washers, 7MM
U
V
W
X
Y
12 1/4-20 Flange Nuts
8
6
4
2
1
1
Fiber Washers
#8x3/8" Self-Tap Dacromat Screws
#8x3/8" Self-Tap Screws
#8x3/8" Screws
Hitch Pin
Wing Nut
Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Grille à gaz naturel Briquettes)®, Char-Diamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, Faststart®, Flare Fighter®, FlavorMaster®, Grille à gaz naturel
Silouette and Design®, H2O Smoker®, Lava Flame®, MasterFlame®, MasterFlame Precision Cooking System®, PowerSpark®, Quantum®, VIP®, PrecisionFlame and Design®, Sierra®, and TruFlame® are registered Trademarks of the W.C.
Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates.
Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking Collection and
Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™, SmokerTents™, The Big Easy™, The Minute Grill™, The Edge™, The Tuscan Collection™, and The Urban Grill™ are Trademarks of the W.C. Bradley
Company. Universal Grill Parts and Design™ is a trademark of the Thermos Company and its affiliates.
Protected under one or more of the following U.S. Patents: 4,598,692; 4,624,240; 4,747,391; 4,747,391; 4,817,583; 4,924,846; 4,989,579; 5,003,960; 5,076,256; 5,076,257; 5,090,398; 5,109,834; 5,224,676; 5,277,106; 5,421,319; 5,441,226;
5,452,707; 5,458,309; 5,566,606; 5,566,606; 5,579,755; 5,582,094; 5,613,486; 5,649,475; 5,706,797; 5,711,663; 5,765,543; 5,931,149; 5,996,573; 6,095,132; 6,135,104; 6,173,644B1; 6,279,566; 6,397,731; 6,418,923; 6,439,222; 6,523,461;
D282,619; D339,714; D341,292; D343,337; D358,059; D361,466; D364,535; D372,637; D373,701; D377,735; D383,035; D397,910; D405,643; D405,643; D406,005; D406,009; D413,043; D413,229; D413,229; D414,982; D415,388; D416,164;
D416,441; D416,441; D417,587; D422,516; D423,274; D423,876; D428,303; D435,396; D436,004; D438,059; D438,060; D438,427; D439,110; D442,505; D443,179; D443,354; D447,384; D447,385; D447,909; D448,610; D448,614; D448,615;
D448,616; D448,975; D449,492; D451,759; D456,202S; D460,313, D461,359 and D504,048. Canada: 87743; 87744; 92607; 92608 and 1,316,424. Other Patents Pending. Assembly instructions © 2006.
12 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
PARTS DIAGRAM – Model No. 463360408
Q
E
P
P
O
G
D
B
O
F
B
HH
C
A
H
U
GG
S
T
K
V
R
I
DD
EE
L
II
J
L
M
L
M
FF
M
W
X
N
Y
Z
BB
AA
CC
463360408 • 13
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
ASSEMBLY – Model No. 463360408
•Place legs as shown (A). Left leg assembly has large holes on ends of legs. Hook tank exclusion wire
into right and left leg assemblies (B).
1
Tank Exclusion Wire
A
Right Leg Assembly
Match Holder
Left Leg Assembly
B
14 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
•Place bottom shelf with cut out hole for LP cylinder next to legs with axle holes. Attach to right and left leg assemblies with 1/4-
20x1-1/2" screws and 1/4-20 flange nuts.
2
1/4-20
Flange Nut
Qty. 4
1/4-20x1-1/2"
Machine Screw
Qty. 4
Bottom Shelf
463360408 • 15
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
•Stand cart upright.
•Attach front panel to cart with #8x3/8" screws.
3
Front Panel
Qty. 6
#8x3/8"
Self-Tap Screw
•Turn assembly upside down.
•Insert axle rod into wheel, wheel spacer, legs and other spacer and wheel. Attach with a axle washer and hitch pin.
4
•Push leg extenders into right legs.
Leg Extenders
1” Hitch Pin
Qty. 1
Wheel Spacer
Qty. 2
Axle Washer
Qty. 1
Wheel Spacer
Axle Rod
Wheel
Wheel Spacer
Axle Washer
Hitch
Pin
"Cone" side of wheel against leg
16 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
•Stand cart upright.
•This step requires two people to lift and position grill head onto cart.
•Carefully lower the grill head onto the cart. Make sure the regulator hose is hanging outside the cart. Attach with 1/4-20x1/2"
screws, 7mm lock washers and 7mm flat washers.
5
Grill Head
Qty. 4
Qty. 4
Qty. 4
7mm Flat Washer
7mm Lock Washer
1/4-20x1/2"
Machine Screw
463320107 • 17
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
•Hook side wall of shelf over support brackets on side of firebox (A).
•Inside firebox insert fiber washers and 1/4-20x1/2" screws as shown (B).
•Attach shelf with flange nuts on each side (C).
6
Qty. 4
1/4-20
Qty. 4
Qty. 4
Fiber Washer
1/4-20x1/2"
Flange Nut
Machine Screw
B
Right Side Shelf
A
C
•Attach fascia to firebox with #8x3/8" self-tap screws.
7
Qty. 2
Fascia, Right Side Shelf
#8x3/8"
Self-Tap Screw
18 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
•Hook side wall of sideburner shelf over support brackets on side of firebox (A).
•Inside firebox insert fiber washers and 1/4-20x1/2" screws as shown (B).
•Attach sideburner shelf with flange nuts on each side (C).
8
•Attach fascia to firebox with #8x3/8" self-tap screws (D).
Qty. 4
Qty. 4
Fiber Washer
1/4-20x1/2"
Machine Screw
A
Qty. 4
1/4-20
Qty. 2
#8x3/8"
Sideburner Shelf
Flange Nut
Self-Tap Screw
B
Back of cart
C
Left Fascia
D
463360408 • 19
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
• Attach sideburner bezel and valve with (2) #8x3/8" screws (A).
•Place sideburner into shelf (B). Make sure valve is inside sideburner tube. Attach sideburner with wing nut (C). Hook burner clip to
sideburner tube and around manifold. Attach sideburner ignitor wire (D)
•Press sideburner control knob onto valve stem (E).
9
•Place grate onto sideburner shelf (F).
Qty. 2
Qty. 1
#8x3/8" Screw
Wing Nut
A
B
Sideburner Bezel
Sideburner Valve
Sideburner
Correctly assembled burner-to-valve engagement
C
D
Burner Clip
Sideburner Ignitor Wire
F
E
Sideburner Grate
Sideburner Control Knob
20 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
•Place heat tents over burners by inserting tabs into slots in front of firebox. Opposite
ends of heat tents rest on pins in back of firebox.
10
11
Pin
•Place cooking grates onto grate rests.
•Insert ends of Swing Away pivot wire into holes in sides of grill lid. Insert ends of Swing Away leg wire into holes in sides of firebox.
NOTE: Pivot and leg wires, running side-to-side, should be under wires running front-to-back. If pivot and leg wires are on top,
Swing Away is installed upside-down.
•Unscrew ignitor cap and place AA battery into ignitor slot with positive end (+) facing outward. Screw ignitor cap onto ignitor.
Swing Away
Pivot Wire
Leg Wire
Cooking Grate
-
+
AA Battery
463360408 • 21
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
•Hang grease cup clip from bottom of firebox and place grease cup into grease clip.
12
Grease Cup Clip
Grease Cup
CAUTION
Failure to install grease cup clip and cup
will cause hot grease to drip from bottom
of grill with risk of fire or property damage.
•LP tank is sold separately. Use only with an OPD (over-fill protection device) equipped LP tank. Fill and leak check before attaching
to grill and regulator.
13
•Place LP tank into hole in bottom shelf with tank collar opening facing to side as shown. Finger tighten tank thumbscrew to hold LP
tank securely in place.
See Use and Care section to correctly Leak Test and
perform the Burner Flame Check.
CAUTION
• Failure to install tank correctly may allow gas hose to
be damaged in operation, resulting in the risk of fire.
LP Tank
Tank Thumbscrew
22 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.
Emergencies
Possible Cause
Prevention/Solution
Gas leaking from
cracked/cut/burned
hose.
• Damaged hose.
• Turn off gas at LP cylinder or at source on natural gas systems. If
anything but burned, replace valve/hose/regulator. If burned,
discontinue use of product until a plumber has investigated cause
and corrections are made.
Gas leaking from LP
cylinder.
• Mechanical failure due to rusting or
mishandling.
• Replace LP cylinder.
Gas leaking from LP
cylinder valve.
• Failure of cylinder valve from
• Turn off LP cylinder valve. Return LP cylinder to gas supplier.
mishandling or mechanical failure.
Gas leaking between
LP cylinder and
• Improper installation, connection not
tight, failure of rubber seal.
• Turn off LP cylinder valve. Remove regulator from cylinder and
visually inspect rubber seal for damage. See LP Cylinder Leak Test
and Connecting Regulator to the LP Cylinder.
regulator connection.
Fire coming through
control panel.
• Fire in burner tube section of burner due
to blockage.
• Turn off control knobs and LP cylinder valve. Leave lid open to
allow flames to die down. After fire is out and grill is cold, remove
burner and inspect for spider nests or rust. See Natural Hazard
and Cleaning the Burner Assembly pages.
Grease fire or
• Too much grease buildup in burner area.
• Turn off control knobs and LP cylinder valve. Leave lid open to
allow flames to die down. After cooling, clean food particles and
excess grease from inside firebox area, grease tray, and other
surfaces.
continuous excessive
flames above cooking
surface.
Troubleshooting
Problem
Possible Cause
Prevention/Solution
GAS ISSUES:
Burner(s) will not light
using ignitor.
• Trying to light wrong burner.
• See instructions on control panel and in Use and Care section.
• Make sure valves are positioned inside of burner tubes.
(See Electronic Ignition
Troubleshooting also)
• Burner not engaged with control valve.
• Obstruction in burner.
• Ensure burner tubes are not obstructed with spider webs or other
matter. See cleaning section of Use and Care.
Continued on next
page.
• No gas flow.
• Make sure LP cylinder is not empty. If LP cylinder is not empty,
refer to “Sudden drop in gas flow.”
• Vapor lock at coupling nut to LP cylinder.
• Turn off knobs and disconnect coupling nut from LP cylinder.
Reconnect and retry.
• Coupling nut and LP cylinder valve not
fully connected.
• Turn the coupling nut approximately one-half to three-quarters
additional turn until solid stop. Tighten by hand only - do not use
tools.
ELECTRICAL ISSUES:
• Electrode cracked or broken; “sparks at
crack.”
• Replace electrode(s).
• Electrode tip not in proper position.
Main Burners:
• Tip of electrode should be pointing toward gas port opening on
burner. The distance should be 1/8” to 1/4”. Adjust if necessary.
Sideburner:
• Tip of electrode should be pointing toward gas port opening on
burner. the distance should be 1/8” to 3/16”. Adjust if necessary.
• Wire and/or electrode covered with
cooking residue.
• Clean wire and/or electrode with rubbing alcohol and clean swab.
• Wires are loose or disconnected.
• Reconnect wires or replace electrode/wire assembly.
• Replace ignitor wire/electrode assembly.
• Wires are shorting (sparking) between
ignitor and electrode.
• Dead battery.
• Replace with a new AA-size alkaline battery.
463360408 • 23
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
Troubleshooting (continued)
Problem
Possible Cause
Prevention/Solution
Burner(s) will not light
using ignitor.
ELECTRONIC IGNITION:
• No spark, no ignition noise.
• See Section I of Electronic Ignition System.
• See Section II of Electronic Ignition System.
• See Section III of Electronic Ignition System.
(See Electronic Ignition
Troubleshooting also)
• No spark, some ignition noise.
• Sparks, but not at electrode or at full
strength.
PIEZO PUSH-BUTTON AND ROTARY:
• Push-button sticks at bottom.
• Replace ignitor.
• Replace knob.
• Rotary knob rotates without clicking.
• Sparking between ignitor and electrode.
• Inspect wire insulation and proper connection. Replace wires if
insulation is broken.
Burner(s) will not
match light.
• See “GAS ISSUES:” on previous page.
• Match will not reach.
• Use long-stem match (fireplace match).
• Improper method of match-lighting.
• See “Match-Lighting” section of Use and Care.
Sudden drop in gas
flow or low flame.
• Out of gas.
• Check for gas in LP cylinder.
• Excess flow valve tripped.
• Turn off knobs, wait 30 seconds and light grill. If flames are still low,
turn off knobs and LP cylinder valve. Disconnect regulator.
Reconnect regulator and leak-test. Turn on LP cylinder valve, wait
30 seconds and then light grill.
• Vapor lock at coupling nut/LP cylinder
connection.
• Turn off knobs and LP cylinder valve. Disconnect coupling nut from
cylinder. Reconnect and retry.
Flames blow out.
Flare-up.
• High or gusting winds.
• Low on LP gas.
• Turn front of grill to face wind or increase flame height.
• Refill LP cylinder.
• Excess flow valve tripped.
• Refer to “Sudden drop in gas flow” above.
• Grease buildup.
• Clean burners and inside of grill/firebox.
• Trim fat from meat before grilling.
• Excessive fat in meat.
• Excessive cooking temperature.
• Adjust (lower) temperature accordingly.
Persistent grease fire.
• Grease trapped by food buildup around
burner system.
• Turn knobs to OFF. Turn gas off at LP cylinder. Leave lid in position
and let fire burn out. After grill cools, remove and clean all parts.
Flashback...
• Burner and/or burner tubes are blocked.
• Turn knobs to OFF. Clean burner and/or burner tubes. See burner
cleaning section of Use and Care.
(fire in burner tube(s)).
Unable to fill LP
cylinder.
• Some dealers have older fill nozzles
with worn threads.
• The worn nozzles don’t have enough “bite” to engage the valve. Try
a second LP dealer.
One burner does not
light from other
burner(s).
• Grease buildup or food particles in
end(s) of carryover tube(s).
• Clean carry-over tube(s) with wire brush.
24 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
Troubleshooting - Electronic Ignition
Problem (Ignition)
Possible Cause
Check Procedure
Prevention/Solution
SECTION I
• Battery not installed
properly.
• Check battery orientation.
• Install battery (make sure that “+” and “–”
connectors are oriented correctly, with “+” end up
and “–” end down.)
No sparks appear at
any electrodes when
ignition button is
pushed; no noise can
be heard from spark
module.
• Dead battery.
• Has battery been used
previously?
• Replace battery with new AA-size alkaline battery.
• Button assembly not
installed properly.
• Check to insure threads are
properly engaged. Button
should travel up and down
without binding.
• Unscrew button cap assembly and reinstall, making
sure threads are aligned and engaged fully.
• Faulty spark module.
• If no sparks are generated
with new battery and good
wire connections, module is
faulty.
• Replace spark module assembly.
SECTION II
• Output lead
connections not
connected.
• Are output connections on
and tight?
• Remove and reconnect all output connections at
module and electrodes.
No sparks appear at
any electrodes when
ignition switch is
pushed; noise can be
heard from spark
module.
SECTION III
• Output lead
connections not
connected.
• Are output connections on
and tight?
• Remove and reconnect all output connections at
module and electrodes.
Sparks are present
but not at all
electrodes and/or not
at full strength
• Arcing to grill away
from burner(s).
• If possible, observe grill in
dark location. Operate
ignition system and look for
arcing between output wires
and grill frame.
• If sparks are observed other than from burner(s),
wire insulation may be damaged. Replace wires.
• Weak battery.
• All sparks present but weak
or at slow rate.
• Replace battery with a new AA-size alkaline battery.
• Use paper towel to remove moisture.
• Electrodes are wet.
• Has moisture accumulated
on electrode and/or in burner
ports?
• Electrodes cracked or
broken “sparks at
crack”.
• Inspect electrodes for
cracks.
• Replace cracked or broken electrodes.
463360408 • 25
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
LIMITED WARRANTY
Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after
correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.
The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid, by the consumer, for review and
examination.
One year LIMITED warranty
Upon consumer supplying proof of purchase as provided herein, Manufacturer will repair or replace the parts listed below which are proven
defective during the applicable warranty period. Parts required to complete such repair or replacement shall be free of charge to you except for
shipping costs. The original consumer-purchaser will be responsible for all shipping charges of parts replaced under the terms of this
limited warranty.
This limited warranty is applicable in the United States and Canada only, is only available to the original owner of the product and is not
transferable. Manufacturer requires reasonable proof of your date of purchase. Therefore, you should retain your sales slip or invoice and register
your new product immediately. Defective or missing parts subject to this limited warranty will not be replaced without registration and proof of
Use & Care manual included with this product and retain your sales receipt for proof of purchase.
This limited warranty applies to the functionality of the product ONLY and does not cover cosmetic issues such as scratches, dents, corrosions
or discoloring by heat, abrasive and chemical cleaners or any tools used in the assembly or installation of the appliance, surface rust, or the
discoloration of stainless steel surfaces. The warranty for your grill covers manufacturing defects. Surface rust, corrosion, or powder paint chipping on
metal parts that does not affect the structural integrity of the product is not considered a defect in workmanship or material and is not covered by this
warranty.
This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or property damage.
If an original replacement part is not available, a comparable replacement part will be sent. You will be responsible for all shipping charges of
parts replaced under the terms of this limited warranty.
ITEMS MANUFACTURER WILL NOT PAY FOR:
1. Service calls to your home.
2. Repairs when your product is used for other than normal, single-family household or residential use.
3. Damage resulting from accident, alteration, misuse, abuse, fire, flood, acts of God, improper installation, installation not in accordance with
electrical or plumbing codes, or use of products not approved by the manufacturer.
4. Any food loss due to product failures.
5. Replacement parts or repair labor costs for units operated outside the United States or Canada.
6. Pickup and delivery of your product.
7. Repairs to parts or systems resulting from unauthorized modifications made to the product.
8. The removal and/or reinstallation of your product.
9. Shipping cost, standard or expedited, for warranty and replacement parts.
DISCLAIMER OF IMPLIED WARRANTIES; LIMITATION OF REMEDIES
Repair or replacement of defect parts is your exclusive remedy under the terms of this limited warranty. Manufacturer will not be responsible for
any consequential or incidental damages arising from the breach of either this limited warranty or any applicable warranty, or for failure or damage
resulting from acts of God, improper care and maintenance, grease fire, accident, alteration,
replacement of parts by anyone other than Manufacturer, misuse, transportation, commercial use, abuse, hostile environments (inclement weather,
acts of nature, animal tampering), improper installation or installation not in accordance with local codes or printed manufacturer instructions.
THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE
SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET FORTH
IN THIS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE, INCLUDING IMPLIED
WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY LIMITED IN DURATION TO THE
DURATION OF THIS LIMITED WARRANTY.
Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise
remedies in addition to or inconsistent with those stated above.
Manufacturer’s maximum liability, in any event, shall not exceed the documented purchase price of the product paid by the original consumer.
This warranty only applies to units purchased from an authorized retailer and or re-seller.
NOTE: Some states do not allow an exclusion or limitation of incidental or consequential damages, so some of the above limitations or
exclusions may not apply to you. This limited warranty gives you specific legal rights as set for herein. You may also have other rights which vary
from state to state. In the state of California only, if refinishing or replacement of the product is not commercially practicable, the retailer selling this
product or the Manufacturer will refund the purchase price paid for the product, less the amount directly attributable to use by the original consumer-
purchaser prior to discovery of the nonconformity. In addition, in the state of California only, you may take the product to the retail establishment
selling this product in order to obtain performance under this limited warranty.
If you wish to obtain performance of any obligation under this limited warranty, you should write to:
Char-Broil Consumer Relations
P. O. Box 1240
Columbus, GA 31902-1240
Consumer returns will not be accepted unless a valid Return Authorization is first acquired by calling 1-800-241-7548 and then clearly marked
on the outside of the package and the package is shipped freight/postage pre-paid to the address above.
26 • 463360408
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
Please register your product online at:
(If you register online, you do not need to send in this registration card.)
PLEASE FILL OUT THIS CARD AND RETURN IT WITHIN 10 DAYS OF PURCHASE. FAILURE TO RETURN MAY AFFECT YOUR WARRANTY COVERAGE. FOR WARRANTY
SERVICE PROOF OF PURCHASE WILL BE REQUIRED. PLEASE KEEP YOUR SALES RECEIPT. THIS WARRANTY IS NON-TRANSFERABLE.
LLENE ESTA TARJETA Y DEVUELVALA DENTRO DE LOS 10 DIAS DE LA COMPRA. SI NO LA DEVUELVE, PUEDE VERSE AFECTADA SU COBERTURA DE GARANTIA.
PARA EL SERVICIO DE GARANTIA ES NECESARIO QUE PRESENTE SU COMPROBANTE DE COMPRA. CONSERVE LA FACTURA. ESTA GARANTIA ES INTRANSFERIBLE.
VEUILLEZ COMPLETER CETTE CARTE ET LA RETOURNER DANS LES 10 JOURS SUIVANT L’ACHAT. LA COUVERTURE DE VOTRE GARANTIE POURRAIT EN ETRE
AFFECTEE SI VOUS NE LE FAITES PAS. POUR OBTENIR LE SERVICE SOUS GARANTIE, UNE PREUVE D’ACHAT DOIT ETRE PRESENTEE. VEUILLEZ CONSERVER
VOTRE FACTURE. LA PRESENTE GARANTIE N’EST PAS TRANSFERABLE.
First Name/Nombre/Prénom
Initial/Inicial/Initiale Last Name/Apellido/Nom de famille
1
2
O
O
Apt Number/N de apart./N d’appt.
Address (number and street)/Dirección (número y calle)/Adresse (numéro et rue)
State/Estado/Province
Zip Code/Código zip/Code postal
City/Ciudad/Ville
E-mail Address/Dirección de correo electrónico/Adresse électronique
If you voluntarily provide us with your email address, you give us permission to use your email address to send you offers that may interest you.
Si nos informa voluntariamente su dirección de correo electrónico, nos da permiso para usarlo a fin de enviarle ofertas que pueden interesarle.
Si vous choisissez de nous fournir votre adresse électronique, vous nous donnez la permission de l’utiliser pour vous faire part d’offres spéciales susceptibles
de vous intéresser.
(Example: your name @ your host.com)
(Ejemplo: su nombre@su host.com)
(Exemple : votre nom@votre hôte.com)
Phone Number/Número telefónico/Numéro de téléphone
Date of Purchase/Fecha de compra/Date de l’achat
Store Name/Nombre de la tienda/Nom du magasin
Purchase Price/Precio de compra/Prix d’achat
3
4
6
7
8
IMPORTANT!/¡IMPORTANTE!/IMPORTANT!
Write Serial Number and Model Number in spaces below.
Escriba en los espacios de abajo el número de serie y el número
de modelo.
Inscrivez le numéro de série et le numéro de modèle dans les
espaces ci-dessous.
$
.00
Your Gender/Sexo/Sexe :
1. Male/Masculino/Masculin
2. Female/Femenino/Féminin
5
9
Which product are your registering?
Mail to: / Envíelo a:
¿Qué producto está registrando?
Consumer Warranty Service
P. O. Box 1240
Quel produit enregistrez-vous?
1. Gas Grill/Parrilla a gas/Gril au gaz
2. Electric Grill/Parrilla eléctrica/Gril électrique
3. Smoker/Ahumador/Fumoir
Columbus, GA 31902-1240
4. Charcoal Grill/Parrilla a carbón/Barbecue au charbon
5. Charcoal Smoker/Ahumador a carbón/Fumoir au charbon
6. Outdoor Fireplace/Chimenea para exteriores/Foyer extérieur
7. Cooker/Fryer / Cocina/freidora / Cuiseur/Friteuse
8. Other/Otro/Autre
Thank you for completing this questionnaire. Your answers will help us and other companies reach you with offers that may interest you. If you prefer not to
receive these offers, please check here
Gracias por completar este cuestionario. Sus respuestas nos ayudarán, a nosotros y a otras compañías, a llegar a usted con ofertas que puedan resultarle
de interés. Si prefiere no recibir estas ofertas, por favor marque aquí
.
.
Merci d’avoir bien voulu remplir ce questionnaire. Vos réponses nous aideront et aideront d’autres compagnies à vous communiquer des offres spéciales
susceptibles de vous intéresser. Si vous préférez ne pas recevoir d’informations concernant ces offres spéciales, veuillez cocher ici
.
463360408 • 27
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
STOP
Should you encounter a problem with our product
CALL US FIRST
Do not return this product to the store.
WE CAN HELP
GRILL SERVICE CENTER
1-800-241-7548
HOURS 8AM-6PM EST Mon-Fri
Please ensure your warranty registration is complete.
Grilling Safety Checklist
Read and understand owners manual.
Never overfill LP cylinder. Overfilled cylinders may cause freeze-up of
regulator.
Check tubes for spider webs. Ensure valves are correctly installed in
burner tubes.
Always ensure control knobs are in OFF position and regulator is
attached to tank BEFORE opening tank valve to avoid low flames.
Perform leak test regularly.
Thank You for Your Purchase!
Char-Broil, LLC • Columbus, GA 31902 • Printed in China
Télécharger from Www.Somanuals.com. All Manuals Search And Télécharger.
|